Tag Archives: wash

Laundry Science: Length of the Wash Cycle (Sometimes a Quickie Isn’t Enough)

eggtimerIn our on-going laundry science series here at the N&G blog, we’ve looked at “the swish factor,” water quality, and how important it is to use plenty of water, but does it matter how long your wash cycle is?


As you’ll remember from our discussion about why using plenty of water is important, part of what makes washing diapers different than washing any other type of laundry is that most of the dirtiness is on the inside, rather than just sitting on the surface. Obviously, it’s going to take extra time to get all that water through the diaper rather than just dealing with the dirt and grime on the surface.

Let’s take a look at the washing routine recommended by many diaper manufacturers and then discuss why they even make these recommendations:
*Rinse on cold
*Long wash on warm or hot
*Double rinse

Why Take the Time?

“Rinse on cold” – You need to have sufficient time to loosen and drain away any lingering nasties – you know, like the uric acid that’s been sitting on the diaper for two days and those little pieces of poo that remain after dumping the solids in the toilet. It’s sort of the same reason as why you scrape your dishes before you put them in the dishwasher – the more gunk the washer has to deal with, the more cycles you’re going to have to do in order to get them truly clean.

“Long wash on warm or hot” – You need time to activate and fully dissolve the detergent and give it time to do its work. Different detergents require different amounts of time to become fully activated. The length of time required for this will depend on the type of detergent, the temperature of your water, the amount of water, as well as the water quality.  Once it’s fully activated and doing its work, it needs sufficient time to fully bond with the grime so the grime can be lifted from the fabric and washed away.

“Double rinse” – You need to allow time for the detergent to be completely washed away too. If you skip this part of the cycle, it’s easy for detergent residue to be left on your lovely fluffy fibres, which can cause leaks, diaper rash, and possibly even extra-stinky diapers because of a chemical reaction that happens when urine hits that detergent residue the next time the diaper is used.

These recommendations certainly apply no matter what type of washing machine you have, but they are even more important if you have an HE machine. Since you have to trick your machine into using enough water and there’s not much swish to have sufficient cleaning action, allowing enough time is absolutely crucial.

And of course, when you’re done washing, you’ve got lots of options for drying your diapershanging them on a line, drying them on a rack, or tossing them in the dryer. Just like the wash needs plenty of time to restore them to their glorious fluffy state, we hope whatever method you use to dry them will give YOU plenty of time to rejuvenate yourself as well!

Laundry Science: C’mon, Baby, Do the Swish

Berlin, Deutschlandtreffen, tanzende JugendlicheHere at New & Green, we love diapers. This also tends to mean we love laundry. Not that it’s always been that way, but there’s something about clean cloth diapers freshly dried that is so… well, yummy-smelling and satisfying.

But if you’re battling diapers that don’t come out so fresh, that’s not so fun. In our new “Laundry Science” series, we’ll tackle various aspects of what laundry scientists think about when they’re designing detergents and machines designed to get your fibres clean.

Today, let’s talk about swish.

The lovely ladies over at the Rockin’ Green blog describe swish this way: “Swish or agitation is a very important component of any good wash routine. The diapers need to not only move around in the wash tub, but they also need to rub up against one another.  Think of how you wash your hands – do you run them under water to get lather, or do you rub your hands together?
With too many diapers in a load, they just rotate around the tub in a bunch. Not enough diapers and they swim around the wash basin blissfully (and dirtily) unaware of their neighbors. So if you have a top loader, load the machine to about the halfway point. For a front loader, you want to have enough items in the drum to where you can put a hands width between the top of the drum and the clothing.”

And don’t worry about this wearing out your diapers – they were designed to rub together in the wash. In fact, it actually “fluffs” them a bit, which makes sure excess oils that affect absorbency are removed, it creates more space between the fibres, which also increases absorbency, and it softens them.

So, now – here’s a bit of homework – next time you do your diaper laundry, look in the wash basin while everything is getting washed and see how all the fabrics interplay. We bet your next load will be extra fresh and clean.

Photo credit Christa Hochneder

How to Wash Cloth Diapers

How to Wash Cloth Diapers

Over the past year, I have answered several thousand questions about washing cloth diapers. The funny thing is a portion of those emails aren’t even about our cloth diaper detergent. Many moms come to us asking for help with the detergent that they have on hand, and we are more than happy to help whenever possible. More babies in cloth is good for everyone! The most common question I get asked is about the “perfect” cloth diaper wash routine.
It seems like everyone has a “perfect” routine. They have a “tried and true” method on what works for them, and they are eager to share it with others. Unfortunately, as many of you have found out, what works for one person won’t work for another.  This can make a seemingly simple process very complicated!
But here at Rockin’ Green, we think of washing diapers as a math problem: 1 + 1 + 1+ 1+ 1 =5.

There are 5 variables that come into play in the wash cycle, and once you understand these variables, you can adjust accordingly to get the best results possible. Sometimes there are things that you just can’t change, so you have to work around them.

waterVariable #1: Your water.

This is something that we talk about A LOT at Rockin’ Green, and for good reason. Water is the first and the most important thing that goes into your washing machine. It dilutes and carries away soils, and allows the detergent to do its job. But tap water is never pure. It contains impurities like minerals that can bind with detergent, and actually make it more difficult to get a good clean. This is one of those variables that you don’t have much control over (unless you invest money in a water softener), so your best plan of attack is to know what you are working with and compensate for it with the other variables like detergent.

Variable # 2 The Swish.

washing-machineI recently had a customer who was battling the dreaded stink, and couldn’t for the life of her figure out why she had such trouble getting her diapers clean. Her wash routine sounded fine, she washed a small load every night, but still the stink endured. Then one day she got backed up on laundry and ended up doing 2 days worth of diapers instead of her usual one. And the diapers came out much better. She learned an important lesson about the power of the “swish”.  Swish or agitation is a very important component of any good wash routine. The diapers need to not only move around in the wash tub, but they also need to rub up against one another.  Think of how you wash your hands- do you run them under water to get lather, or do you rub your hands together?
With too many diapers in a load, they just rotate around the tub in a bunch. Not enough diapers and they swim around the wash basin blissfully (and dirtily) unaware of their neighbors. So if you have a top loader, load the machine to about the halfway point. For a front loader, you want to have enough items in the drum to where you can put a hands width between the top of the drum and the clothing.

Variable # 3 Temperature

thermometerMost machines have 3 settings. Cold, warm or hot….and as cloth diapering guru’s you should be pretty familiar with the basic cloth diaper wash routine. Do a rinse on cold, a wash on hot, and then another rinse on cold, but there are some variables even in that. First off, what is your water heater set at? This can have a direct effect on how clean your diapers are. Most bacteria die when the water reaches a temp of 130-140 degrees (and many detergent ingredients react faster in this temp range), so an adjustment in your water heater can make a big difference. Most diaper manufacturers warn against temps of 150 and over when PUL is involved, so keep your water heater set at around 130 for day to day washings. Note: It will usually come out of the tap about 10 degrees cooler
Disclaimer: Always check with your diaper manufacturer regarding recommended wash procedure and temperature thresholds, especially when PUL is involved.

Temperature can also play a part when it comes to stains. Did you know that the best way to treat a stain is by rinsing it out at the same temperature that the stain was created? So leave the cold rinsing for ice cream stains, and move the dial to warm for poop stains. They were created at 98.6 after all!

Variable #4 Time fixes all

“Rock a Soak” has become a common cloth diapering term, and there is some science behind it. The amount of time that your diapers are in the wash will also help determine your outcome. The chemicals in your detergent have different reaction times that can be affected by things like temperature and water quality, so you may find that a longer wash cycle in some cases gets you better results, because it allows the detergent to actually do its job as opposed to being flushed down the drain. If you have really hard water, or a water heater that isn’t up to par….you can lengthen your wash cycle to compensate. Note: this is why front loader cycles take FOREVER because they have to make up for the lack of swish.

Variable #5 Detergent (You didn’t think we would forget that did you?)

photoAs a detergent manufacturer you would think that we would place this at the top of the list, but that just isn’t the case. Don’t get me wrong, I think that Rockin’ Green cloth diaper detergent rocks – but its one piece of the puzzle. Within that black and green bag, you have the tools to overcome things like poor water quality and hardness (which is why we have 3 different formulas based on your water type), but you have to find the sweet spot there too. Generally speaking you want to start off with 1-3 tbs, but you may adjust up or down depending on the other 4 variables.
Another tip: when it comes time to add the soap, try dropping down the water level in your machine.  This will increase the concentration of soap and the swish!  So in your initial and post rinses, you want to keep the water level high but in your hot wash with the soap try dropping it down to a medium water level. This should give you a better clean!

Ok….so seriously, just tell me what a “perfect” routine is already Kim!

By now, you probably know that there is no perfect routine. The key to finding the sweet spot is to look at every piece of the puzzle, and then adjust as needed. You may need to add a little more soap to make up for an overstuffed washer, crank up your water heater to make up for a lack of swish in your front loader, or lengthen the time your diapers spend in the washer to make up for hard water. And the list goes on and on….
I hope this helps some of you struggling with finding the “perfect” wash routine! Check us out at www.RockinGreenSoap.com for more wash tips and tools.

And be on the lookout for Funk Rock- Ammonia Buster – Coming Soon!

Tags: , , , , , ,

48 Responses to “How to Wash Cloth Diapers”

  1. I’m so glad you wrote this! I always read your answers to washing problems but now that I know all the variables we can intelligently make changes! We are not using Hard Rock and should be and we don’t fill the front loader enough– we wash 8 diapers every night. We thought we were preventing stink doing that but maybe doing a load every other day will help!

  2. Monica says:

    Ooh Funk Rock… sounds like something I need! How soon is it coming?? I’m having stinky ammonia issues!

  3. Maria says:

    That’s the most common suggestion I get and I say pretty much the same things you do, LOL! I wish there was a one-size-fits-all answer!

  4. Missy says:

    Thank you for posting this. I have messed with a couple of different variables trying to figure it out, but there are a couple I missed.

  5. marie says:

    thank you! i’m having so much trouble finding the right wash routine with my front loader. this will help me tremendously!

  6. Emily says:

    Ooooooh, Funk Rock!!! I’ll be trying that out as soon as it’s available.

  7. Arice says:

    I really thought this was a personal note for me. I have been struggling with my new- not so new- front loader which we have had since Aug and still not getting it right. I am back to Motley Crue but thinking I need to venture into soft rock. So glad to have checked out you site. love the suggestions.

  8. Carrie says:

    I think this is a great post – When well-meaning moms share their “perfect” routine, and the moms with diaper problems can’t ever get it fixed, even using different “perfect” routines, it sets people up for thinking cloth diapers are too much trouble!

    Recognizing that an individual’s situation makes a difference in how one should wash is an important idea!

    I think, though, that even the variables you listed can have variance from the recommendation you put out. For instance: Washer capacity is variable, even in front loaders. I have a super capacity front load washer that has something like 4.6 cubic feet of drum space. This is more than most residential front load washers out there. If I were to fill my washer up till i had just a hand span between the top of the diaper pile and the washer drum, I believe that I would have more than 50 cloth diaper items (not including wipes). I would have to wait almost all week to have enough diapers, based on that criteria. I haven’t tried to fill the washer that much with diapers, but maybe I’ll have to give it a go, and see what happens!

  9. … track backe bei http://colombianadas.info/reinaldoalipio/ ……

    très bon , votre weblog disposition style est certainement bon , Je suis chasse tout nouveau disposition style pour mon moncler doudoune propre personnel blog , j’aime vôtre, maintenant Je vais à aller recherche le similaires thème !…

  10. Kim, I could kiss you! After reading this & adjusting my water level during the wash, my diapers smell fantastic again! No more lingering stinkies I could not get rid of! I am SO stinkin’ (not really!) happy! Thank you for writing this fantastic post that explains the logic behind washing preferences! Woo hoo!!

  11. JESUS says:

    ?????????BUY VIAGRA????????…


  12. CLINTON says:

    ?????????BUY LEVITRA????????…


  13. GUY says:

    symbicort vs advair

    Buyno prescription…

  14. CLYDE says:

    Cialis UK

    Buygeneric meds…

  15. JIMMIE says:

    Actos@official.site” rel=”nofollow”>..

    Buywithout prescription…

  16. RALPH says:

    Aleve@official.site” rel=”nofollow”>..

    Buyit now…

  17. SERGIO says:

    aloe@vera.gel.indicatii” rel=”nofollow”>…

    Buygeneric drugs…

  18. DARRELL says:

    altace@medication.now” rel=”nofollow”>…

    Buygeneric meds…

  19. FERNANDO says:

    Amoxicillin@official.site” rel=”nofollow”>…

    Buyno prescription…

  20. GREGORY says:

    Azor@official.site” rel=”nofollow”>…

    Buygeneric pills…

  21. ENRIQUE says:

    Aricept@official.site” rel=”nofollow”>.


  22. ALBERTO says:

    Crestor@official.site” rel=”nofollow”>.

    Buywithout prescription…

  23. CARLTON says:

    abilify@vs.risperidone.dosage” rel=”nofollow”>.

    Buygeneric drugs…

  24. ARTHUR says:

    where@to.buy.uk.viagra” rel=”nofollow”>.

    Buygeneric pills…

  25. KIRK says:

    buy@viagra.in.london.england” rel=”nofollow”>…

    Buygeneric drugs…

  26. JORDAN says:

    < a href=”http://my.gardenguides.com/members/buy-Cialis? buy@Cialis.now

    Buydrugs without prescription…

  27. GUY says:

    abilify@and.sleep.issues” rel=”nofollow”>.

    Buyno prescription…

  28. ALVIN says:

    < a href=”http://my.gardenguides.com/members/buy-Tramadol? buy@Tramadol.now

    Buyno prescription…

  29. RON says:

    cheap@Viagra.now” rel=”nofollow”>…

    Buygeneric pills…

  30. ANDREW says:

    Risperdal@official.site” rel=”nofollow”>..

    Buynow it…

  31. SEAN says:

    Zyrtec@official.site” rel=”nofollow”>.


  32. RONALD says:

    Depakote@official.site” rel=”nofollow”>.

    Buygeneric drugs…

  33. CHRIS says:


    Buygeneric drugs…

  34. EDWARD says:

    zyban pill

    Buywithout prescription…

  35. VIRGIL says:


    Buyno prescription…

  36. COREY says:


    Buyit now…

  37. REX says:


    Buygeneric drugs…

  38. MAURICE says:

    asperger zoloft 100

    Buydrugs without prescription…

  39. RUSSELL says:


    Buygeneric pills…

  40. PAUL says:

    zoloft works

    Buygeneric pills…

  41. CLINTON says:

    Vitamin E

    Buygeneric drugs…

Leave a Reply

No Washer, No Problem :: Washing Cloth Diapers without Insuite Laundry

For many urbanites, apartment dwelling involves a shared laundry room, coin operated machines, and designated time slots for using the washers and dryers. Can families really still manage cloth diapering in these circumstances? The answer is a resounding “yes, oh YES!”

Dealing with cloth diapers outside of one’s own suite may seem like a nuisance, not to mention expensive when you’re shelling out coins in hand. In reality, it’s quite easy and the cost is usually comparable, if not less, than paying for the extra energy usage on your monthly utility bill.

Here are four tips for using cloth when you don’t have insuite laundry:

Choose cloth diapers that unfold or come apart to wash easily and dry quickly. Pockets, prefolds and flats are great options for this. If you use fitteds or all-in-one’s, choose ones that have multiple, separated layers for ease of washing and drying.

Sign up for time slots or make your schedule to allow you to wash every two or three days. If you can’t get three slots a week, try to sign up for two slots that are 3 ½ days apart, such as a Monday evening and a Friday morning.

Consider line drying. Since most laundry-room machines are coin operated, line drying will certainly save you $$$. If you’ve got the room either in your suite or in your building’s laundry room, give it go. Inexpensive drying racks can be found at Ikea or any hardware store or mass merchandiser.

Do a short cold wash cycle first or choose your own rinse. The fact that many coin-op machines can’t do an isolated rinse cycle adds unwanted cost and time to the washing process. If you prefer to avoid this cost, consider two cheaper and faster ways of rinsing your diapers (and of course, as always, it is preferable that you knocked off all solids into the toilet at the time you changed the diaper!):

In the diaper pail – Place the diaper pail in a large laundry sink or bathtub. Fill with cold water and swish with a stick. Pour out as much water as you can, then dump all the contents into the washer and start your normal hot wash. This method requires a strong back, but try it with the ever popular Planet Wise Pail liners and keep the diaper contained while washing to ensure you never have to touch the dirty diapers!

In a laundry sink – Dump the dirty diapers from your pail into a large laundry sink, fill with cold water, and agitate them with a stick or with your hands. Drain the water from the sink, pressing on the diapers as the water empties. Toss the diapers directly from the sink into the washer and wash on hot with detergent. Presto change-o, you’re done!

With a bit of planning and some considerations about how to save even more money with cloth diapers, laundering in a shared laundry or a coin-op laundry is definitely do-able.

Are you are a “no in-suite cloth diapering family”?  What is your best strategy for making it work for your family?